alarmes (b896)
Post on 13-Jul-2016
15 Views
Preview:
DESCRIPTION
TRANSCRIPT
2200 YRM 1286 General
GeneralThis section describes the Iskra® motor controllerand dash display used in MPE060-F, MPE080-F,
2200 YRM 1286 Parameter Description
Parameter DescriptionPARAMETERS
2200 YRM 1286 Troubleshooting
Table 2. Fault Codes
Code Description
To troubleshoot symptoms that do not generate a fault code, refer to Non-Status CodeErrors, in this section.
Troubleshooting 2200 YRM 1286
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
Troubleshooting 2200 YRM 1286
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
Troubleshooting 2200 YRM 1286
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
Troubleshooting 2200 YRM 1286
Troubleshooting 2200YRM1286
DISPLAY MESSAGE
LED
CIRCUIT
Service Required
SYMPTOM
Troubleshooting 2200 YRM 1286
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
2200 YRM 1286 Troubleshooting
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
2200 YRM 1286 Troubleshooting
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
17170 Service Required Solid Red Traction Motor
DESCRIPTION SYMPTOM
Controller has detected a failure of the traction
2200 YRM 1286 Troubleshooting
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
2200 YRM 1286 Troubleshooting
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
2200 YRM 1286 Troubleshooting
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
33033(cont)
2200 YRM 1286 Troubleshooting
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
2200 YRM 1286 Troubleshooting
STATUSCODE
DISPLAY MESSAGE
Troubleshooting 2200 YRM 1286
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
Troubleshooting 2200 YRM 1286
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
Troubleshooting 2200 YRM 1286
STATUSCODE
DISPLAY MESSAGE LED CIRCUIT
33073 Service Required Solid Red Power Steering
DESCRIPTION
2200 YRM 1286 Troubleshooting
2200 YRM 1286 Electrical Checks
Electrical ChecksGENERAL ELECTRICAL SYSTEMCHECKS
1. Turn the key to the OFF position, disconnect the
2200 YRM 1286 Electrical Checks
a. If resistance is lower than 1 Mohm, check forshorted conditions between components har-ness, and the truck.
b.
2200 YRM 1286 Control Card Functional Test
(4) B and truck frame
(5) UT wire (traction motor) to truck frame
(6)
Dash Display 2200 YRM 1286
Belly Switch and pin 5 of JP1. If no conti-nuity is found, replace control card.
g. SNAIL/TILLER ARM SW wire # wire W355 AC
(1)
Connector Pin-Outs 2200 YRM 1286
Controller Connector (CPS 05)
Pin Wire Number Function
33
34
35
110
NOTES
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
____________________________________________________________
top related